duramax allison transmission cooler upgrade

Filter replacement and pan removal are often included. Remember, all the fluid is replaced in a transmission fluid flush. Pump inlet method can cost a little more than the cooler flush. Are you bringing your car to an independent repair facility, a dealership, or an automotive maintenance provider, like Jiffy Lube? With more than 2,000 locations, there’s sure to be a Jiffy Lube ® near you. Labor costs can be more expensive in urban areas. An ATF flush will cost more in a high-end car

The year, make, and model of your car and transmission.

7 FACTORS THAT CAN AFFECT TRANSMISSION FLUSH COST A flush will take 12 to 22 quarts, while a fluid change requires 5 to 7 quarts. This is due in large part to the additional fluid required. This is approximately twice as much as a transmission fluid change. Therefore, the pump inlet flush method can be more expensive.ĭrivers can expect to pay $125 to $250 for a transmission fluid flush service.

Requires the removal and replacement of the pan and filter.

More complete than the cooler flush method, this method has drawbacks, too: When the system is cleared, new ATF is supplied. Pump inlet flush method: The system is completely flushed, with ATF transferred through the transmission into a drainage pain. Instead, it is continuously diluted with the new ATF.

The old ATF is not completely replaced.

Due to the way the ATF cycles through the unit, some of it will may land into the pan without going to the cooler.While popular, there are downsides to this method: The only difference is that the incoming ATF is clean, and the outgoing, used ATF is stored for recycling. The ATF circulates just as it would under normal operating conditions. This way, no damage is done to the internal parts of the system. The transfer process uses the pressure produced by the transmission pump to circulate the ATF. This allows the ATF to be transferred to and from the flush machine. Then the transmission is inspected for any external signs of problems or leaks.Ĭooler flush method: The lines between the transmission and the cooler will be disconnected and attached to the flush machine. This helps the technician recognize and diagnose any problems that should be addressed during servicing. WHAT HAPPENS DURING A TRANSMISSION FLUID FLUSH SERVICE?įirst, a test drive is performed. Jiffy Lube locations use quality Pennzoil ® products (where available) that meet or exceed OEM (Original Equipment Manufacturer) specifications. If you can’t find your manual, or if more than one ATF is recommended, ask a trained Jiffy Lube ® technician for assistance. Consult your owner’s manual for the manufacturer’s recommendation. So, make sure the right type of transmission fluid is used after your flush or fluid exchange. However, full synthetic may degrade certain transmission components. Full synthetic transmission fluid is more expensive, but it also lasts longer, lubricates better, and is more effective in combatting heat and friction. One that is often recommended - especially for older cars - is synthetic. There are many different types and grades of ATF. Periodically changing ATF will help extend transmission life and may help maintain your vehicle’s warranty. If the fluid isn’t changed, high operating temperatures and contaminants will accelerate transmission wear. As it ages, ATF becomes thin and dirty, losing its ability to remove heat from inside the transmission. WHY ARE TRANSMISSION FLUSH SERVICES NECESSARY?ĪTF lubricates, cools, and cleans the internal transmission parts.

Transmission fluid change cost: Typically, between $80 and $250 the cost varies depending on where the service is performed, what fluid is used, and other factors Transmission flush cost: Typically, $125 to $250 Only drains 20% to 40% of the total ATF volumeĪ trained professional should perform this serviceĭrivers may choose to handle this themselves Runs a special solution through the cooler lines until completely clean, and refills the system with new ATF

Uses natural gravitational forces to drain the ATFĬompletely removes all the ATF from the transmissionįlushes away grime and contaminants from the torque converter and cooler lines Requires a professional-grade flush machine to flush away the ATF (automatic transmission fluid) Let’s look at these two services, how they help keep your car running smooth, and how much you can expect to pay for each. Like a turtle and a tortoise or a malted and a milkshake, a transmission flush and a fluid exchange are similar but different.

Duramax allison transmission cooler upgrade